When to replace the Oil Filter on your FORD MONDEO
Recommended replacement interval for the part category Oil filter : 12 month / 15000 km
Important!
This replacement procedure can be used for:
FORD MONDEO III Estate (BWY) 1.8 16V, FORD MONDEO III Estate (BWY) 2.0 16V, FORD MONDEO III Estate (BWY) 1.8 SCi View more

The steps may slightly vary depending on the car design.

How to change Engine Oil and Oil filter on FORD MONDEO 3 TUTORIAL | AUTODOC

video
Tools
Replacement: engine oil and filter – Ford Mondeo BWY. Tools you need:
All-purpose cleaning spray
Drive socket # 15
Oil filter cup socket 65/14F
HEX bit no.H5
Ratchet wrench
Torque wrench
Flat Screwdriver
Funnel
Oil drain pan
Fender cover
Replacement: engine oil and filter – Ford Mondeo BWY. AUTODOC recommends:
  • Replace the oil filter every time when changing motor oil.
  • Wear gloves to prevent contact with hot liquid.
  • All work should be done with the engine stopped.
Replacement: engine oil and filter – Ford Mondeo BWY. Use the following procedure:
  1. Step 1
    How to change Oil Filter on Ford Mondeo bwy 2000 - free PDF and video manuals
    Lift the car using a jack or place it over an inspection pit.
    Replacement: engine oil and filter – Ford Mondeo BWY. Tip from AUTODOC experts:
    The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All works should be done with the engine cooled down.
  2. Step 2
    How to replace FORD MONDEO III Estate (BWY) 2.0 16V 2001 Oil Filter - step-by-step manuals and video guides
    Clean the oil filter housing cap.
  3. Step 3
    Ford Mondeo bwy 2.0 TDCi 2002 Oil Filter replacement: free workshop manuals
    Loosen the drain plug on the oil filter housing. Use HEX No.H5. Use a ratchet wrench.
  4. Step 4
    Put a waste oil container with at least 5 l capacity under the drainage hole.
    Step 5
    Changing Oil Filter on FORD MONDEO III Estate (BWY) 1.8 16V 2003 by yourself
    Unscrew the drain plug. Use HEX No.H5. Use a ratchet wrench.
  5. Step 6
    How to remove FORD MONDEO 2.2 TDCi 2004 Oil Filter - online easy-to-follow instructions
    Drain the used oil.
    Replacement: engine oil and filter – Ford Mondeo BWY. Tip:
    Caution! The oil may be hot.
  6. Step 7
    How to replace Oil Filter on FORD MONDEO III Estate (BWY) 2005: download PDF manuals and video instructions
    Remove the old sealing ring. Use a flat screwdriver.
  7. Step 8
    How hard is it to do yourself: Oil Filter replacement on Ford Mondeo bwy ST220 3.0 2006 - download illustrated guide
    Install the new sealing ring. Use a flat screwdriver.
  8. Step 9
    Clean the area of the oil pan drainage hole.
    Step 10
    Need to know how to renew Oil Filter on FORD MONDEO 2007? This free workshop manual will help you to do it yourself
    Tighten the drain plug on the oil filter housing. Use HEX No.H5. Use a torque wrench. Tighten it to 11 Nm torque.
  9. Step 11
    Changing of Oil Filter on Ford Mondeo bwy 2000 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the filter housing cap together with the old filter element. Use the 65/14F socket. Use a ratchet wrench.
  10. Step 12
    FORD MONDEO 1.8 SCi Oil Filter replacement: online guides and video tutorials
    Put the old oil filter in the container.
    Replacement: engine oil and filter – Ford Mondeo BWY. Tip from AUTODOC:
    Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
  11. Step 13
    Replacing Oil Filter on Ford Mondeo bwy 2002 2.0 16V by yourself
    Detach the oil filter from the filter cover.
  12. Step 14
    Clean the oil filter housing cap. Use all-purpose cleaning spray.
    Step 15
    MONDEO III Estate (BWY) 2.2 TDCi 2003 Oil Filter DIY replacement workshop manual
    Remove the oil filter cover O-ring. Use a flat screwdriver.
  13. Step 16
    How to change Oil Filter on FORD MONDEO III Estate (BWY) 2004 - tips and tricks
    Install a new O-ring to its mounting seat on the filter cover. Use a flat screwdriver.
  14. Step 17
    Lubricate the rubber seal of the new filter with a little amount of fresh oil.
    Step 18
    Step-by-step recommendations for DIY replacement Ford Mondeo bwy 2005 2.2 TDCi Oil Filter
    Install the new oil filter to the mounting seat on the filter cover.
    Please note!
    Make sure to install the filter correctly. Don't mix up the sides of the part.
  15. Step 19
    Clean the oil filter seat.
    Step 20
    DIY replacement of Oil Filter on FORD MONDEO III Estate (BWY) 2.0 16V TDDi / TDCi 2006 is not an issue anymore with our step-by-step tutorial
    Install a new oil filter housing cover and tighten it. Use the 65/14F socket. Use a torque wrench. Tighten it to 25 Nm torque.
  16. Step 21
    How to change Oil Filter on Ford Mondeo bwy 2000 - free PDF and video manuals
    Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.
  17. Step 22
    Put a waste oil container with at least 5 l capacity under the drainage hole.
    Step 23
    How to replace FORD MONDEO III Estate (BWY) 2.0 16V 2001 Oil Filter - step-by-step manuals and video guides
    Unscrew the drain plug. Use a drive socket #15. Use a ratchet wrench.
  18. Step 24
    Ford Mondeo bwy 2.0 TDCi 2002 Oil Filter replacement: free workshop manuals
    Drain the used oil.
    Replacement: engine oil and filter – Ford Mondeo BWY. Tip from AUTODOC experts:
    Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
  19. Step 25
    Changing Oil Filter on FORD MONDEO III Estate (BWY) 1.8 16V 2003 by yourself
    Clean the area of the oil pan drainage hole.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
FORD MONDEO III Estate (BWY) Oil Filter replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY FORD MONDEO III Estate (BWY) Oil Filter replacement - online guide
Tips & tricks for your FORD MONDEO III Estate (BWY)
View more
  • How to change Oil filters on FORD MONDEO III Estate (BWY) 2.0 16V TDDi / TDCi - replacement tricks
    What causes engine misfire? | AUTODOC
  • Changing Engine oil filter Ford Mondeo bwy 2.0 16V - Replacement Tips
    How to clean an engine bay | AUTODOC
  • Maintenance Hacks - FORD MONDEO III Estate (BWY) 2.0 TDCi Oil filters replacement guide
    How to find and change a fuse | AUTODOC
  • Replace Engine oil filter on Ford Mondeo bwy - free video tips
    Headlight Restoration | AUTODOC tips