Recommended replacement interval for the part category Brake Shoe Set : 100000 km

Important!

This replacement procedure can be used for:
OPEL Tigra Coupe (S93) 1.4 16V (F07), OPEL Tigra Coupe (S93) 1.6 16V (F07), OPEL Tigra Coupe (S93) 1.4 16V (F07), OPEL Tigra Coupe (S93) 1.6 16V (F07) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Shoes for Tigra Coupe (S93) and other OPEL models

Brake Shoe Set

Brake Shoe

        Brake Shoe Set for OPEL Tigra Coupe (S93) 1.4 16V (F07) Petrol (90 hp)
      
        Brake Shoe Set for OPEL Tigra Coupe (S93) 1.6 16V (F07) Petrol (106 hp)
      
        Brake Shoe Set for OPEL Tigra Coupe (S93) 1.4 16V (F07) Petrol (86 hp)
      
        Brake Shoe Set for OPEL Tigra Coupe (S93) 1.6 16V (F07) Petrol (100 hp)

Replacement: brake shoes – OPEL TIGRA (95_). Tools you need:

                        Wire brush
                      
                        WD-40 spray
                      
                        All-purpose cleaning spray
                      
                        Bearing grease
                      
                        Ceramic grease
                      
                        Torque wrench
                      
                        Drive socket # 24 
                      
                        Wheel impact socket #17
                      
                        Brake shoe retaining spring compressor
                      
                        Flat screwdriver
                      
                        Ratchet wrench
                      
                        Long nose pliers
                      
                        Water pump pliers
                      
                        Hammer
                      
                        Rubber mallet
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake shoes – OPEL TIGRA (95_). AUTODOC experts recommend:

Replace brake shoes as a set on an axle. This will ensure efficient braking.
The replacement procedure is identical for brake shoes on the same axle.
Please note: all work on the car – OPEL TIGRA (95_) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Secure the wheels with chocks.

Step 2

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 3

Raise the car.

Replacement: brake shoes – OPEL TIGRA (95_). Tip:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 4

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. OPEL TIGRA (95_)
Step 5

Remove the wheel.
Step 6

Remove the wheel hub nut cap. Use a crowbar. Use a hammer.
Step 7

Remove the cotter pin securing the hub nut. Use a crowbar. Use a flat screwdriver.
Step 8

Unscrew the hub nut. Use a drive socket #24. Use a ratchet wrench.
Step 9

Remove the wheel bearing washer. Use a crowbar.
Step 10

Remove the wheel hub bearing. Use a crowbar.
Step 11

Remove the brake drum assembled with the wheel hub bearing.

Replacement: brake shoes – OPEL TIGRA (95_). Tip from AUTODOC experts:
Examine the brake drum. Replace it if necessary.
Step 12

Clean the fasteners of the brake shoes. Use all-purpose cleaning spray.
Step 13

Loosen the brake shoe adjuster. Use a crowbar.
Step 14

Remove the upper return spring of the brake shoes. Use long nose pliers.
Step 15

Remove the hold-down spring. Use a flat screwdriver.
Step 16

Remove the retainers of the drum brake shoes. Use a brake shoe retaining spring compressor.
Step 17

Detach the brake shoe from the lower spring.
Step 18

Remove the right brake shoe.
Step 19

Remove the lower return spring of the brake shoes.
Step 20

Disconnect the parking brake cable.
Step 21

Remove the left brake shoe.

Replacement: brake shoes – OPEL TIGRA (95_). Tip from AUTODOC:
Don't press the brake pedal after removing the rear brake drum shoes. This will cause the piston to fall out of the brake cylinder, leakage of brake fluid and depressurization of the system.
Step 22

Clean the mounting seats of the brake shoes. Use all-purpose cleaning spray.

Replacement: brake shoes – OPEL TIGRA (95_). Tip from AUTODOC experts:
Make sure to follow the assembly steps in the right order.
Step 23

Connect the parking brake cable to the parking brake lever.
Step 24

Install a new left brake shoe.
Step 25

Install the lower return spring.
Step 26

Remove the upper spring and the adjuster.
Step 27

Remove the circlip. Use a flat screwdriver.
Step 28

Remove the brake shoe adjuster lever.
Step 29

Clean the mounting seat of the bushing. Use a wire brush. Use WD-40 spray.
Step 30

Remove the bushing. Use water pump pliers.
Step 31

Clean the bushing. Use a wire brush.
Step 32

Install the bushing on a new brake shoe. Use water pump pliers.
Step 33

Install the brake shoe adjuster lever.
Step 34

Install the circlip.
Step 35

Install the upper retaining springs and adjustment mechanism on new brake shoes. Use a flat screwdriver.
Step 36

Install a new right brake shoe.
Step 37

Install the lower return spring.
Step 38

Install the retainers of the drum brake shoes. Use a brake shoe retaining spring compressor.
Step 39

Install the hold-down spring.
Step 40

Install the upper return spring. Use long nose pliers.
Step 41

Treat the wheel hub bearing. Use bearing grease.
Step 42

Treat the stub axle. Use all-purpose cleaning spray. Use bearing grease.
Step 43

Readjust the brake shoe adjuster. Use a crowbar.
Step 44

Install the brake drum assembled with the wheel hub bearing.
Step 45

Fit the wheel bearing washer.
Step 46

Screw on the hub nut. Use a drive socket #24. Use a ratchet wrench.
Step 47

Screw in the wheel bolts. Use wheel impact socket #17.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. OPEL TIGRA (95_)
Step 48

Spin the wheel to distribute the new grease evenly on the wheel bearings.
Step 49

Adjust the axial clearance by tightening the adjusting nut. Use a drive socket #24. Use a torque wrench. Tighten it to 20-25 Nm torque.

Please note!
See your car’s repair manual for exact adjustment instructions.
Step 50

Unscrew the wheel bolts.

AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. OPEL TIGRA (95_)
Step 51

Remove the wheel.
Step 52

Install a new hub nut cotter pin. Use a crowbar.
Step 53

Install the cap of the hub nut. Use a rubber mallet.
Step 54

Treat the surface where the wheel rim contacts the brake drum. Use ceramic grease.
Step 55

Install the wheel.

AUTODOC recommends:
Important! Hold the wheel while screwing in the fastening bolts. OPEL TIGRA (95_)
Step 56

Screw in the wheel bolts. Use wheel impact socket #17.
Step 57

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 110 Nm torque.
Step 58

Remove the jacks and chocks.

Replacement: brake shoes – OPEL TIGRA (95_). Tip from AUTODOC:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Check the brake fluid level in the expansion tank and refill if necessary.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change wheel cylinder on OPEL Tigra Coupe (S93) – replacement guide

Free download PDF
2.07 MB
How to change front brake pads on OPEL Tigra Coupe (S93) – replacement guide

Free download PDF
1.46 MB
How to change rear wheel bearing on OPEL Tigra Coupe (S93) – replacement guide

Free download PDF
2.06 MB
How to change spark plugs on OPEL Tigra Coupe (S93) – replacement guide

Free download PDF
1.25 MB
How to change front windshield wipers on OPEL Tigra Coupe (S93) – replacement guide

Free download PDF
1.45 MB
How to change rear windshield wipers on OPEL Tigra Coupe (S93) – replacement guide

Free download PDF
563.2 KB

How to change rear brake shoes on OPEL Tigra TwinTop (X04) – replacement guide

Free download PDF
2.94 MB
How to change rear brake shoes on Opel Corsa C – replacement guide

Free download PDF
1.67 MB
How to change rear brake shoes on Opel Corsa S93 – replacement guide

Free download PDF
2.99 MB
How to change rear brake shoes on OPEL COMBO (71_) – replacement guide

Free download PDF
1.57 MB
How to change rear brake shoes on OPEL Astra F Classic CC (T92) – replacement guide

Free download PDF
1.57 MB
How to change rear brake shoes on OPEL Astra F Classic Saloon (T92) – replacement guide

Free download PDF
1.57 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Coolant comparison test | AUTODOC

11K views

Published on: 18/02/2021
How to restore wheel rims | AUTODOC tips

6K views

Published on: 13/05/2021
TOP 6 WD-40 lifehacks | AUTODOC tips

12K views

Published on: 15/07/2021
4 reasons why your CHECK ENGINE light is on | AUTODOC tips

6K views

Published on: 30/03/2022