How to carry out replacement: Brake Pads 1.3 CDTI 16V (F08, W5L) Opel Corsa C Van
Disclaimer
Change Opel Corsa C Van 1.7 DI 16V (F08, W5L) Brake Pads yourself – manuals and video tutorials

How to change rear brake pads on OPEL Corsa C Van (X01) – replacement guide

downloads: 0
Views: 23
Download your free tutorial and fix OPEL Corsa C Van (X01) 1.3 CDTI 16V (F08, W5L) problems yourself Download for free 1.48 MB Brake Pads for Opel Corsa C Van Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your OPEL CORSA
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
OPEL Corsa C Van (X01) 1.7 DTI 16V (F08, W5L), OPEL Corsa C Van (X01) 1.4 (W5L, F08) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Corsa C Van (X01) and other OPEL models
How to change Brake pad set on Opel Corsa C Van 1.3 CDTI 16V (F08, W5L) – step-by-step instructions for straightforward car repair Brake pad set
How to change Brake pad set on Corsa C Van (X01) – tips for proper car maintenance
Brake pad set for Corsa C Van (X01) Diesel (75 hp)
Simple DIY car repair steps – Replacing Brake pad set on Corsa C Van (X01)
Brake pad set for Corsa C Van (X01) Petrol (90 hp)
Tools
Replacement: brake pads – OPEL CORSA C Box (F08, W5L). Tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Copper grease
Torque wrench
Combination spanner #13
Combination spanner #17
Drive socket # 13
Wheel impact socket #17
Brake caliper wind back tool
Water pump pliers
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – OPEL CORSA C Box (F08, W5L). AUTODOC experts recommend:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – OPEL CORSA C Box (F08, W5L) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Pads on Opel Corsa C Van 2000 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 4
    How to replace OPEL Corsa C Van (X01) 1.3 CDTI 16V (F08, W5L) 2001 Brake Pads - step-by-step manuals and video guides
    Raise the rear of the car and secure on supports.
  3. Step 5
    Opel Corsa C Van 1.7 DI 16V (F08, W5L) 2002 Brake Pads replacement: free workshop manuals
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. OPEL CORSA C Box (F08, W5L)
  4. Step 6
    Changing Brake Pads on OPEL Corsa C Van (X01) 1.7 DTI 16V (F08, W5L) 2003 by yourself
    Remove the wheel.
  5. Step 7
    How to remove OPEL CORSA 1.2 (F08, W5L) 2004 Brake Pads - online easy-to-follow instructions
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  6. Step 8
    How to replace Brake Pads on OPEL Corsa C Van (X01) 2005: download PDF manuals and video instructions
    Release the parking brake cable. Use water pump pliers. Use a crowbar.
  7. Step 9
    How hard is it to do yourself: Brake Pads replacement on Opel Corsa C Van 1.4 (W5L, F08) 2006 - download illustrated guide
    Unscrew the brake caliper fastening. Use a combination spanner #13. Use a combination spanner #17.
  8. Step 10
    Need to know how to renew Brake Pads on OPEL CORSA 2007? This free workshop manual will help you to do it yourself
    Spread the brake pads. Use a crowbar.
  9. Step 11
    Changing of Brake Pads on Opel Corsa C Van 2008 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake caliper.
    Replacement: brake pads – OPEL CORSA C Box (F08, W5L). Professionals recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  10. Step 12
    OPEL CORSA 1.7 DI 16V (F08, W5L) Brake Pads replacement: online guides and video tutorials
    Remove the brake pads. Use a crowbar.
    Replacement: brake pads – OPEL CORSA C Box (F08, W5L). Tip from AUTODOC experts:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  11. Step 13
    Replacing Brake Pads on Opel Corsa C Van 2010 1.3 CDTI 16V (F08, W5L) by yourself
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – OPEL CORSA C Box (F08, W5L). After applying the spray, wait a few minutes.
  12. Step 14
    Corsa C Van (X01) 1.2 (F08, W5L) 2011 Brake Pads DIY replacement workshop manual
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – OPEL CORSA C Box (F08, W5L). Tip from AUTODOC:
    Make sure the disc surface is clean before installing the pads.
  13. Step 15
    How to change Brake Pads on OPEL Corsa C Van (X01) 2012 - tips and tricks
    Install new brake pads.
    Replacement: brake pads – OPEL CORSA C Box (F08, W5L). Tip:
    Make sure the pads are installed with linings facing the disc.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the OPEL Corsa C Van (X01) model.

Browse tyres

Popular maintenance tutorials for Opel Corsa C Van

More manuals for Opel Corsa C Van

Complete guides for changing the Brake pad set on different OPEL CORSA models

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
OPEL Corsa C Van (X01) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY OPEL Corsa C Van (X01) Brake Pads replacement - online guide
Tips & tricks for your OPEL Corsa C Van (X01)
View more
  • How to change Brake pad set on OPEL Corsa C Van (X01) 1.2 16V (F08, W5L) - replacement tricks
    How and why to check your oil | AUTODOC tips
    5K views
    Published on: 23/02/2023
  • Changing Disc pads Opel Corsa C Van 1.3 CDTI 16V (F08, W5L) - Replacement Tips
    How to choose the right engine oil for your car | AUTODOC
    8K views
    Published on: 01/07/2020
  • Maintenance Hacks - OPEL Corsa C Van (X01) 1.7 DI 16V (F08, W5L) Brake pad kit replacement guide
    How to remove scratches from a car | AUTODOC tips
    7K views
    Published on: 12/05/2022
  • Replace Disc brake pads on Opel Corsa C Van - free video tips
    How to polish your car | AUTODOC tips
    5K views
    Published on: 31/03/2022

Most commonly replaced car parts on OPEL CORSA

Professional manuals for the most common OPEL models