Recommended replacement interval for the part category Brake Pad Set, disc brake : 30000 km

Important!

This replacement procedure can be used for:
MERCEDES-BENZ VANEO (414) 1.7 CDI (414.700), MERCEDES-BENZ VANEO (414) 1.6 (414.700), MERCEDES-BENZ VANEO (414) 1.6 (414.700), MERCEDES-BENZ VANEO (414) 1.9 (414.700), MERCEDES-BENZ VANEO (414) 1.7 CDI (414.700) … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for VANEO (414) and other MERCEDES-BENZ models

Brake Pad Set, disc brake

        Brake Pad Set, disc brake for MERCEDES-BENZ VANEO (414) 1.7 CDI (414.700) Diesel (75 hp)
      
        Brake Pad Set, disc brake for MERCEDES-BENZ VANEO (414) 1.6 (414.700) Petrol (102 hp)
      
        Brake Pad Set, disc brake for MERCEDES-BENZ VANEO (414) 1.6 (414.700) Petrol (82 hp)
      
        Brake Pad Set, disc brake for MERCEDES-BENZ VANEO (414) 1.9 (414.700) Petrol (125 hp)
      
        Brake Pad Set, disc brake for MERCEDES-BENZ VANEO (414) 1.7 CDI (414.700) Diesel (91 hp)

Replacement: brake pads – MERCEDES-BENZ VANEO (414). List of the tools you'll need:

                        Wire brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        Combination spanner #13
                      
                        Combination spanner #15
                      
                        Drive socket # 13 
                      
                        Wheel impact socket #H12
                      
                        Torque wrench
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – MERCEDES-BENZ VANEO (414). AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – MERCEDES-BENZ VANEO (414) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the bonnet.Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.
Step 3

Loosen the wheel mounting bolts.Use wheel impact socket #H12.
Step 4

Raise the rear of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:

To avoid injury, hold up the wheel when unscrewing the bolts.
Step 6

Remove the wheel.
Step 7

Clean the brake caliper fasteners. Use a wire brush.Use WD-40 spray.
Step 8

Unscrew the brake caliper fastening.Use a combination spanner #13.Use a combination spanner #15.
Step 9

Spread the brake pads.Use a crowbar.
Step 10

Remove the brake caliper.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). AUTODOC recommends:

Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Remove the brake pads.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). Tip from AUTODOC:

Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12

Clean the brake caliper bracket from dirt and dust.Use a wire brush.Use a brake cleaner.

AUTODOC recommends:

Replacement: brake pads – MERCEDES-BENZ VANEO (414). After applying the spray, wait a few minutes.
Step 13

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). Professionals recommend:

Make sure the disc surface is clean before installing the pads.
Step 14

Install new brake pads.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). Tip from AUTODOC:

Make sure the pads are installed with linings facing the disc.
Step 15

Treat the brake caliper piston.Use a brake cleaner.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). Tip:

After applying the spray, wait a few minutes.
Step 16

Press in the brake caliper piston.Use brake caliper wind back tool.
Step 17

Install the brake caliper and fix it.Use a combination spanner #13.Use a combination spanner #15.Use a drive socket #13.Use a torque wrench.Tighten it to 35 Nm torque.
Step 18

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 19

Clean the brake disk surface.Use a brake cleaner.

AUTODOC recommends:

Replacement: brake pads – MERCEDES-BENZ VANEO (414). After applying the spray, wait a few minutes.
Step 20

Install the wheel.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). AUTODOC recommends:

To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 21

Screw in the wheel bolts.Use wheel impact socket #H12.
Step 22

Lower the car and working in a cross order, tighten the wheel bolts.Use wheel impact socket #H12.Use a torque wrench.Tighten it to 130 Nm torque.
Step 23

Remove the jacks and chocks.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). AUTODOC experts recommend:

Check the brake fluid level in the expansion tank and refill if necessary.
Step 24

Tighten the brake fluid reservoir cap.

AUTODOC recommends:

MERCEDES-BENZ VANEO (414) – Press the brake pedal several times with the engine shut down until you feel the resistance built up.

Step 25

Close the hood.

Replacement: brake pads – MERCEDES-BENZ VANEO (414). Tip:

Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Comment

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change serpentine belt on MERCEDES-BENZ Vaneo (W414) – replacement guide

Free download PDF

1.34 MB
How to change spark plugs on MERCEDES-BENZ Vaneo (W414) – replacement guide

Free download PDF

1.69 MB
How to change front windshield wipers on MERCEDES-BENZ Vaneo (W414) – replacement guide

Free download PDF

1.38 MB
How to change fuel filter on MERCEDES-BENZ Vaneo (W414) – replacement guide

Free download PDF

2.1 MB
How to change ignition coil on MERCEDES-BENZ Vaneo (W414) – replacement guide

Free download PDF

1.46 MB
How to change front wheel bearing on Mercedes W203 – replacement guide

Free download PDF

14.99 MB

How to change rear brake pads on Mercedes W169 – replacement guide

Free download PDF

6.32 MB
How to change front brake pads on Mercedes W202 – replacement guide

Free download PDF

7.63 MB
How to change front brake pads on Mercedes W169 – replacement guide

Free download PDF

6.53 MB
How to change front brake pads on Mercedes Vito W639 – replacement guide

Free download PDF

8.31 MB
How to change rear brake pads on Mercedes Vito W639 – replacement guide

Free download PDF

7.5 MB
How to change front brake pads on Mercedes W210 – replacement guide

Free download PDF

8.56 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Tips & tricks for your MERCEDES-BENZ VANEO (414)

Causes of a worn car boot damper | AUTODOC

2K views

Published on: 04/07/2021
Top 6 products for enhancing your car | AUTODOC

2K views

Published on: 18/11/2021
How to remove rust | AUTODOC tips

11K views

Published on: 16/09/2021
What to check when buying a used car | AUTODOC tips

4K views

Published on: 24/10/2020