How to change rear brake pads on BMW 3 Convertible (E93) – replacement guide
downloads:
2
Views:
26
0
Users voted – 0
Recommended replacement interval for the part category Brake pad set : 30000km
Important!
This replacement procedure can be used for:
BMW 3 Convertible (E93) 318 i,
BMW 3 Convertible (E93) 320 i,
BMW 3 Convertible (E93) 325 i,
BMW 3 Convertible (E93) 325 i,
BMW 3 Convertible (E93) 320 d,
BMW 3 Convertible (E93) 320 d,
BMW 3 Convertible (E93) 325 i,
BMW 3 Convertible (E93) 320 i,
BMW 3 Convertible (E93) 320 i,
BMW 3 Convertible (E93) 320 d,
BMW 3 Convertible (E93) 320 d,
BMW 3 Convertible (E93) 320 d
…
View more
The steps may slightly vary depending on the car design.
This video shows the replacement procedure of a similar car part on another vehicle
All the parts you need to replace – Brake Pads for 3 Convertible (E93) and other BMW models
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11
Remove the brake pads. Use a flat screwdriver.
Step 12
Remove the brake pads retaining clips.
Use a flat screwdriver.
Step 13
Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
AUTODOC recommends:
Replacement: brake pads – BMW 3 Convertible (E93). After applying the spray, wait a few minutes.
Step 14
Install the brake pads retaining clips.
Step 15
Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
AUTODOC recommends:
Make sure the disc surface is clean before installing the pads.
Step 16
Install new brake pads.
Replacement: brake pads – BMW 3 Convertible (E93). Tip:
Make sure the pads are installed with linings facing the disc.
Step 17
Treat the brake caliper piston. Use a brake cleaner.
AUTODOC recommends:
Replacement: brake pads – BMW 3 Convertible (E93). After applying the spray, wait a few minutes.
Step 18
Press in the brake caliper piston. Use brake caliper wind back tool.
Step 19
Install the brake caliper and fix it. Use a combination spanner #15. Use a drive socket #13. Use a torque wrench. Tighten it to 35 Nm torque.
Step 20
Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 21
Clean the brake disk surface. Use a brake cleaner.
Replacement: brake pads – BMW 3 Convertible (E93). Tip from AUTODOC experts:
After applying the spray, wait a few minutes.
Step 22
Install the wheel.
AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. BMW 3 Convertible (E93)
Step 23
Screw in the wheel bolts. Use wheel impact socket #17.
Step 24
Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 120 Nm torque.
Replacement: brake pads – BMW 3 Convertible (E93). Tip:
Without starting the engine, press the brake pedal several times until you feel significant resistance.
Step 25
Remove the jacks and chocks.
AUTODOC recommends:
Check the brake fluid level in the expansion tank and refill if necessary.
Step 26
Tighten the brake fluid reservoir cap. Close the hood.
Replacement: brake pads – BMW 3 Convertible (E93). AUTODOC recommends:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- scan the QR code
- download from App Store
- download from Google Play
Tips & tricks for your BMW 3 Convertible (E93)
View more
How to paint a car with a spray can | AUTODOC tips
How to clean an engine bay | AUTODOC
What to do if the belt squeals | AUTODOC tips
How to prevent car windows from fogging up | AUTODOC tips