How to carry out replacement: Brake Pads 1.4 AUDI A2 (8Z0)
Disclaimer
Change AUDI A2 (8Z0) 1.4 Brake Pads yourself – manuals and video tutorials

How to change rear brake pads on AUDI A2 (8Z0) – replacement guide

downloads: 3
Views: 48
Download your free tutorial and fix AUDI A2 (8Z0) 1.6 FSI problems yourself Download for free 1.36 MB Brake Pads for AUDI A2 (8Z0) Shop now
Leave a comment Open in a new tab
When to replace the Brake Pads on your AUDI A2
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
AUDI A2 (8Z0) 1.6 FSI, AUDI A2 (8Z0) 1.4 TDI … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for A2 (8Z0) and other AUDI models
How to change Brake pad set on AUDI A2 (8Z0) 1.4 – step-by-step instructions for straightforward car repair Brake pad set
How to change Brake pad set on A2 (8Z0) – tips for proper car maintenance
Brake pad set for A2 (8Z0) Petrol (110 hp)
Simple DIY car repair steps – Replacing Brake pad set on A2 (8Z0)
Brake pad set for A2 (8Z0) Diesel (90 hp)
Tools
Replacement: brake pads – AUDI A2 (8Z0). List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Anti-squeal paste
Ceramic grease
Torque wrench
Combination spanner #13
Combination spanner #15
Drive socket # 13
Wheel impact socket #17
Brake caliper wind back tool
Crow bar
Wheel chock
Buy tools
Replacement: brake pads – AUDI A2 (8Z0). Tip from AUTODOC:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – AUDI A2 (8Z0) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Pads on AUDI A2 (8Z0) 2000 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 4
    Raise the car.
    Replacement: brake pads – AUDI A2 (8Z0). Tip:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 5
    How to replace AUDI A2 (8Z0) 1.4 2001 Brake Pads - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. AUDI A2 (8Z0)
  3. Step 6
    AUDI A2 (8Z0) 1.4 TDI 2002 Brake Pads replacement: free workshop manuals
    Remove the wheel.
  4. Step 7
    Changing Brake Pads on AUDI A2 (8Z0) 1.6 FSI 2003 by yourself
    Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
  5. Step 8
    How to remove AUDI A2 1.4 2004 Brake Pads - online easy-to-follow instructions
    Unscrew the brake caliper fasteners. Use a combination spanner #13. Use a combination spanner #15.
  6. Step 9
    How to replace Brake Pads on AUDI A2 (8Z0) 2005: download PDF manuals and video instructions
    Remove the brake caliper. Use a crowbar.
    Replacement: brake pads – AUDI A2 (8Z0). Tip from AUTODOC experts:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  7. Step 10
    How hard is it to do yourself: Brake Pads replacement on AUDI A2 (8Z0) 1.2 TDI 2000 - download illustrated guide
    Remove the brake pads.
    AUTODOC recommends:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  8. Step 11
    Need to know how to renew Brake Pads on AUDI A2 2001? This free workshop manual will help you to do it yourself
    Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
    AUTODOC recommends:
    After applying the spray, wait a few minutes.
  9. Step 12
    Changing of Brake Pads on AUDI A2 (8Z0) 2002 won't be an issue if you follow this illustrated step-by-step guide
    Press in the brake caliper piston. Use brake caliper wind back tool.
  10. Step 13
    AUDI A2 1.4 Brake Pads replacement: online guides and video tutorials
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – AUDI A2 (8Z0). After applying the spray, wait a few minutes.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 14
    Replacing Brake Pads on AUDI A2 (8Z0) 2004 1.4 by yourself
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – AUDI A2 (8Z0). Tip from AUTODOC:
    Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the AUDI A2 (8Z0) model.

Browse tyres

Popular maintenance tutorials for AUDI A2 (8Z0)

More manuals for AUDI A2 (8Z0)

Complete guides for changing the Brake pad set on different AUDI A2 models

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
AUDI A2 (8Z0) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY AUDI A2 (8Z0) Brake Pads replacement - online guide
Tips & tricks for your AUDI A2 (8Z0)
View more
  • How to change Brake pad set on AUDI A2 (8Z0) 1.2 TDI - replacement tricks
    How to paint a car with a spray can | AUTODOC tips
    5K views
    Published on: 25/03/2021
  • Changing Disc pads AUDI A2 (8Z0) 1.4 - Replacement Tips
    How do EGR valves work? | AUTODOC
    18K views
    Published on: 18/07/2020
  • Maintenance Hacks - AUDI A2 (8Z0) 1.4 TDI Brake pad kit replacement guide
    Coolant comparison test | AUTODOC
    11K views
    Published on: 18/02/2021
  • Replace Disc brake pads on AUDI A2 (8Z0) - free video tips
    DIY brake caliper restoration | AUTODOC tips
    554K views
    Published on: 02/06/2022

Most commonly replaced car parts on AUDI A2

Professional manuals for the most common AUDI models