Recommended replacement interval for the part category Fuel filter : 60000 km

Important!

This replacement procedure can be used for:
PEUGEOT EXPERT Platform/Chassis 2.0 HDi 120, PEUGEOT EXPERT Platform/Chassis 2.0 HDi 140 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Fuel Filter for EXPERT Platform/Chassis and other PEUGEOT models

Fuel filter

Fuel filter for Expert II Platform/Chassis Diesel (120 hp)

Simple DIY car repair steps – Replacing Fuel filter on Expert II Platform/Chassis

Fuel filter for Expert II Platform/Chassis Diesel (136 hp)

Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. Tools you might need:

                        All-purpose cleaning spray
                      
                        Drive socket # 27 
                      
                        Ratchet wrench
                      
                        Flat Screwdriver
                      
                        Clip removal tool
                      
                        Hand-operated fluid syringe

                        Fluid container
                      
                        Fender cover

Buy tools

Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
All work should be done with the engine stopped.

Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. Recommended sequence of steps:

Step 1

Open the hood.

Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 3

Remove the engine cover.

AUTODOC recommends:
Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. To avoid damaging the part during installation, do not use excessive force.
Step 4

Clean the fasteners of the fuel supply lines. Use all-purpose cleaning spray.
Step 5

Detach the fuel pressure sensor connector. Use a flat screwdriver.
Step 6

Squeeze the clips and detach the fuel supply lines from the fuel filter housing. Use a flat screwdriver. Use a clip removal tool.

Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. Tip:
Be careful! Fuel may leak from the filter housing and hoses.
Step 7

Close the fuel lines with caps.
Step 8

Unscrew the fasteners of the fuel filter housing cover. Use a drive socket #27. Use a ratchet wrench.
Step 9

Remove the fuel filter cover with the old filter cartridge attached.
Step 10

Prepare a container for fluids.

Step 11

Put the fuel filter cover with the old filter cartridge into a container.
Step 12

Pump the fuel out of the fuel filter housing. Use a hand-operated fluid syringe.
Step 13

Remove the old sealing ring. Use a flat screwdriver.
Step 14

Remove the fuel filter.
Step 15

Clean the fuel filter housing and the cover. Use all-purpose cleaning spray.
Step 16

Install the new sealing ring.
Step 17

Install a new fuel filter.

Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. AUTODOC recommends:
Make sure that the fuel filter is positioned correctly. Consider the fuel flow direction mark.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 18

Install the fuel filter cover with the filter cartridge attached.
Step 19

Tighten the fasteners of the fuel filter cover. Use a drive socket #27. Use a ratchet wrench. Remove the caps from the fuel lines.
Step 20

Connect the fuel lines to the fuel filter and lock the fastening clips.
Step 21

Attach the fuel pressure sensor connector.
Step 22

Clean the fuel lines. Use all-purpose cleaning spray.
Step 23

Press the fuel primer pump several times until it gets hard.
Step 24

Install the engine cover and secure it.

Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. Professionals recommend:
Make sure the engine cover is properly seated. It should not be displaced with respect to the guiding fasteners.Do not apply excessive force when installing the part. Otherwise you may damage the fasteners.
Step 25

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 26

Shut off the engine.

Step 27

Remove the fender protection cover.

Step 28

Close the hood.

Replacement: fuel filter – PEUGEOT EXPERT Platform/Chassis. Tip from AUTODOC:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the PEUGEOT Expert II Platform/Chassis model.

Browse tyres

How to change engine oil and filter on PEUGEOT Expert II Platform/Chassis – replacement guide

Free download PDF
3.1 MB
How to change serpentine belt on PEUGEOT EXPERT Platform/Chassis – replacement guide

Free download PDF
716.8 KB
How to change spark plugs on PEUGEOT EXPERT Platform/Chassis – replacement guide

Free download PDF
1.4 MB
How to change rear windshield wipers on PEUGEOT Expert II Platform/Chassis – replacement guide

Free download PDF
1.41 MB
How to change front windshield wipers on PEUGEOT EXPERT Platform/Chassis – replacement guide

Free download PDF
532.48 KB
How to change right engine mounts on PEUGEOT EXPERT Platform/Chassis – replacement guide

Free download PDF
1.49 MB

How to change fuel filter on PEUGEOT Expert Tepee (VF3X_) – replacement guide

Free download PDF
931.84 KB
How to change fuel filter on PEUGEOT EXPERT Box (VF3A_, VF3U_, VF3X_) – replacement guide

Free download PDF
931.84 KB
How to change fuel filter on PEUGEOT EXPERT Box (222) – replacement guide

Free download PDF
901.12 KB
How to change fuel filter on PEUGEOT Expert (224_) – replacement guide

Free download PDF
901.12 KB
How to change fuel filter on PEUGEOT EXPERT Platform/Chassis (223) – replacement guide

Free download PDF
901.12 KB
How to change fuel filter on a car – replacement tutorial

Universal

Free download PDF
2 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

TOP 6 WD-40 lifehacks | AUTODOC tips

12K views

Published on: 15/07/2021
How to check your head gasket | AUTODOC

4K views

Published on: 03/12/2020
Car checks you need to carry out on your car after the winter | AUTODOC tips

3K views

Published on: 23/03/2023
5 car interior cleaning mistakes | AUTODOC tips

6K views

Published on: 26/05/2022