Recommended replacement interval for the part category Fuel filter : 4 year / 60000 km

Important!

This replacement procedure can be used for:
OPEL Corsa B Hatchback (S93) 1.2 i (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 i (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 Si (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.6 GSI 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.6 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.0 i 12V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.2 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.2 i (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.6 i 16V (F08, F68, M68), OPEL Corsa B Hatchback (S93) 1.4 (F08, F68, M68) … View more

The steps may slightly vary depending on the car design.

How to change fuel filter OPEL CORSA S93 [TUTORIAL AUTODOC]

All the parts you need to replace – Fuel Filter for Corsa B Hatchback (S93) and other OPEL models

Fuel filter

        Fuel filter for OPEL Corsa B Hatchback (S93) 1.2 i (F08, F68, M68) Petrol (45 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.4 i (F08, F68, M68) Petrol (60 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.4 Si (F08, F68, M68) Petrol (82 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.6 GSI 16V (F08, F68, M68) Petrol (109 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.4 i 16V (F08, F68, M68) Petrol (90 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.6 i 16V (F08, F68, M68) Petrol (106 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.0 i 12V (F08, F68, M68) Petrol (54 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.2 i 16V (F08, F68, M68) Petrol (65 hp)
      
        Fuel filter for OPEL Corsa B Hatchback (S93) 1.2 i (F08, F68, M68) Petrol (45 hp)

Replacement: fuel filter – Opel Corsa S93. Tools you might need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        All-purpose cleaning spray
                      
                        Fuel line pliers
                      
                        Phillips Screwdriver
                      
                        Fluid container

Buy tools

Replacement: fuel filter – Opel Corsa S93. AUTODOC experts recommend:

Ensure adequate ventilation of the workplace. Fuel vapors are poisonous.
Please note: all work on the car – Opel Corsa S93 – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the fuel door.
Step 2

Unscrew the fuel filler cap.
Step 3

Raise the car.

Replacement: fuel filter – Opel Corsa S93. Professionals recommend:
If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
Step 4

Prepare a container for fluids.
Step 5

Clean the fasteners of the fuel supply lines. Use a nylon cleaning brush. Use all-purpose cleaning spray.
Step 6

Clean the fuel filter mounting bracket. Use a wire brush. Use all-purpose cleaning spray.
Step 7

Unscrew the fuel filter bracket. Use a Phillips screwdriver.
Step 8

Remove the fuel filter.
Step 9

Disconnect the fuel supply lines from the fuel filter. Use fuel line pliers.

Replacement: fuel filter – Opel Corsa S93. AUTODOC recommends:
Be careful! Fuel may leak from the filter housing and hoses.
Step 10

Put the old filter cartridge in the container.

Step 11

Connect the fuel supply lines to the fuel filter.
Step 12

Install a new fuel filter.

Replacement: fuel filter – Opel Corsa S93. Tip:
Remember, it is important not to mix up the input and output of the filter. Arrows on the filter indicate the direction of fuel flow.During installation, take care to prevent dust and dirt from getting into the fuel filter housing.Take care to only use quality filters.
Step 13

Screw in the fuel filter mounting bracket. Use a Phillips screwdriver.
Step 14

Clean the fuel filter. Use all-purpose cleaning spray.
Step 15

Take the fluid container away from under the fuel filter.
Step 16

Lower the car.
Step 17

Tighten the fuel filler cap.
Step 18

Close the fuel door.

AUTODOC recommends:
Before starting off, switch the ignition on and off several times. This should be done to activate the fuel pump to make it pump fuel through the fuel system.
Step 19

Run the engine for a few minutes. This is necessary in order to make sure that the component operates properly.

Step 20

Shut off the engine.

Replacement: fuel filter – Opel Corsa S93. AUTODOC experts recommend:
To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change engine oil and filter on Opel Corsa S93 – replacement guide

Free download PDF
2.72 MB
How to change pollen filter on Opel Corsa S93 – replacement guide

Free download PDF
1.67 MB
How to change air filter on Opel Corsa S93 – replacement guide

Free download PDF
1.17 MB
How to change front brake pads on Opel Corsa S93 – replacement guide

Free download PDF
1.65 MB
How to change front brake discs on Opel Corsa S93 – replacement guide

Free download PDF
2.1 MB
How to change front wheel bearing on Opel Corsa S93 – replacement guide

Free download PDF
4.74 MB

How to change fuel filter on Opel Corsa D – replacement guide

Free download PDF
1.38 MB
How to change fuel filter on OPEL Corsa E Hatchback (X15) – replacement guide

Free download PDF
1.01 MB
How to change fuel filter on Opel Corsa C petrol – replacement guide

Free download PDF
870.4 KB
How to change fuel filter on Opel Corsa C diesel – replacement guide

Free download PDF
1.33 MB
How to change fuel filter on OPEL Corsa A CC (S83) petrol – replacement guide

Free download PDF
706.56 KB
How to change fuel filter on OPEL Corsa A TR (S83) petrol – replacement guide

Free download PDF
706.56 KB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

TOP 5 mistakes during DIY oil change | AUTODOC tips

34K views

Published on: 17/06/2021
How to check your head gasket | AUTODOC

4K views

Published on: 03/12/2020
How to fix your car with AUTODOC CLUB

16K views

Published on: 30/11/2021
3 things that cause engine damage | AUTODOC tips

9K views

Published on: 07/10/2021