Important!

This replacement procedure can be used for:
SKODA Octavia I Box Body / Estate (1U5) 1.9 TDI, SKODA Octavia I Box Body / Estate (1U5) 1.9 D … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Control Arm for Octavia I Box Body / Estate (1U5) and other SKODA models

Suspension arm

Link Set, wheel suspension

How to change Suspension arm on SKODA Octavia I Box Body / Estate (1U5) 1.9 TDI – tips for proper car maintenance

Suspension arm for SKODA Octavia I Box Body / Estate (1U5) 1.9 TDI Diesel (90 hp)

Simple DIY car repair steps – Replacing Suspension arm on SKODA Octavia I Box Body / Estate (1U5) 1.9 D

Suspension arm for SKODA Octavia I Box Body / Estate (1U5) 1.9 D Diesel (68 hp)

Replacement: front lower arm – SKODA Octavia I Kasten / Kombi (1U5). List of the tools you'll need:

                        Combination spanner #18
                      
                        Drive socket # 16 
                      
                        Drive socket # 18 
                      
                        HEX bit No.H8.
                      
                        WD-40 spray
                      
                        Copper grease 
                      
                        Wire brush
                      
                        Torque wrench
                      
                        Wheel impact socket #17
                      
                        Hydraulic transmission jack
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: front lower arm – SKODA Octavia I Kasten / Kombi (1U5). Tip from AUTODOC experts:

The replacement procedure is identical for the left and right lower control arms.
All work should be done with the engine stopped.

Replacement: front lower arm – SKODA Octavia I Kasten / Kombi (1U5). Take the following steps:

Step 1

Secure the wheels with chocks.
Step 2

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 3

Raise the front of the car and secure on supports.
Step 4

Unscrew the wheel bolts.

Replacement: front lower arm – SKODA Octavia I Kasten / Kombi (1U5). AUTODOC recommends:
To avoid injury, hold up the wheel when unscrewing the bolts.
Step 5

Remove the wheel.
Step 6

Disconnect the transverse stabilizer fastener from the link. Use a drive socket #16. Use HEX No.H8.
Step 7

Turn the stabilizer.
Step 8

Unscrew the ball joint fastening nut. Use a combination spanner #18.
Step 9

Unscrew the front arm fastener. Use a drive socket #16.
Step 10

Unscrew the rear arm fastener. Use a drive socket #18.
Step 11

Unscrew the ball joint fastening to the steering knuckle.
Step 12

Remove the arm.

Replacement: front lower arm – SKODA Octavia I Kasten / Kombi (1U5). Professionals recommend:
If necessary, use a crowbar.
Step 13

Clean all joints of the arm. Use a wire brush. Treat all joints of the arm. Use WD-40 spray.

Replacement: front lower arm – SKODA Octavia I Kasten / Kombi (1U5). Tip from AUTODOC:
Wear protective goggles.
Step 14

Install a new arm.
Step 15

Insert the ball joint into the steering knuckle and fix it with a new nut.

Replacement: front lower arm – SKODA Octavia I Kasten / Kombi (1U5). AUTODOC experts recommend:
Do not damage the ball joint cover.
Step 16

Install the front fastener of the arm. Do not tighten it.
Step 17

Install the rear fastener of the arm.
Step 18

Tighten the ball joint fastening nut. Use a combination spanner #18.
Step 19

Support the arm. Use a hydraulic transmission jack.
Step 20

Screw the front arm fastener. Important! Be sure to use new fasteners. Use a drive socket #16. Use a torque wrench. Tighten it to 70 Nm torque.+90°
Step 21

Screw the rear arm fastener. Important! Be sure to use new fasteners. Use a drive socket #18. Use a torque wrench. Tighten it to 70 Nm torque.+90°
Step 22

Tighten the ball joint fastening nut. Important! Be sure to use new fasteners. Use a combination spanner #18. Use a torque wrench. Tighten it to 45 nm torque.
Step 23

Install the rod fastening to the stabilizer and tighten it. Important! Be sure to use new fasteners. Use a drive socket #16. Use HEX No.H8. Use a torque wrench. Tighten it to 15 Nm torque.+90°
Step 24

Clean the wheel rim mounting seat. Use a wire brush. Treat the contacting surface. Use copper grease.
Step 25

Install the wheel.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while screwing in the fastening bolts on the car. SKODA Octavia I Kasten / Kombi (1U5)
Step 26

Screw in the wheel bolts. Use wheel impact socket #17.
Step 27

Lower the car and working in a cross order, tighten the wheel bolts. Use a torque wrench. Tighten it to 120 nm torque.
Step 28

Remove the jacks and chocks.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

How to change rear strut mount on SKODA Octavia I Box Body / Estate (1U5) – replacement guide

Free download PDF
2.13 MB
How to change front strut mount on SKODA Octavia I Box Body / Estate (1U5) – replacement guide

Free download PDF
1.76 MB
How to change front anti roll bar links on SKODA Octavia I Box Body / Estate (1U5) – replacement guide

Free download PDF
1.12 MB
How to change track rod end on SKODA Octavia I Box Body / Estate (1U5) – replacement guide

Free download PDF
2.3 MB
How to change rear brake pads on SKODA Octavia I Box Body / Estate (1U5) – replacement guide

Free download PDF
1.54 MB
How to change front brake pads on SKODA Octavia I Box Body / Estate (1U5) – replacement guide

Free download PDF
1.38 MB

How to change front lower arm on SKODA OCTAVIA (1Z3) – replacement guide

Free download PDF
1.9 MB
How to change rear suspension lower control arm on SKODA OCTAVIA (1Z3) – replacement guide

Free download PDF
1.63 MB
How to change rear suspension lower trailing arm on SKODA OCTAVIA (1Z3) – replacement guide

Free download PDF
1.67 MB
How to change front lower arm on SKODA Octavia II Combi (1Z5) – replacement guide

Free download PDF
1.9 MB
How to change rear suspension lower control arm on SKODA Octavia II Combi (1Z5) – replacement guide

Free download PDF
1.63 MB
How to change rear suspension lower trailing arm on SKODA Octavia II Combi (1Z5) – replacement guide

Free download PDF
1.67 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

DIY jack restoration | AUTODOC tips

12K views

Published on: 22/09/2022
Replacing your engine cooling fan | AUTODOC tips

2K views

Published on: 15/11/2020
How to detect vacuum leaks using a smoke machine | AUTODOC

19K views

Published on: 23/07/2020
Coolant comparison test | AUTODOC

11K views

Published on: 18/02/2021