When to replace the Brake Pads on your VW GOLF
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
VW Golf V Hatchback (1K1) 1.4 16V, VW Golf V Hatchback (1K1) 2.0 TDI 16V, VW Golf V Hatchback (1K1) 2.0 FSI, VW Golf V Hatchback (1K1) 1.9 TDI, VW Golf V Hatchback (1K1) 1.6 FSI, VW Golf V Hatchback (1K1) 1.4 FSI, VW Golf V Hatchback (1K1) 2.0 SDI, VW Golf V Hatchback (1K1) 1.9 TDI, VW Golf V Hatchback (1K1) 1.9 TDI 4motion, VW Golf V Hatchback (1K1) 2.0 TDI 16V 4motion, VW Golf V Hatchback (1K1) 2.0 FSI 4motion, VW Golf V Hatchback (1K1) 2.0 TDI, VW Golf V Hatchback (1K1) 1.4 TSI, VW Golf V Hatchback (1K1) 2.0 TDI, VW Golf V Hatchback (1K1) 1.4 16V, VW Golf V Hatchback (1K1) 1.4 TSI, VW Golf V Hatchback (1K1) 2.0 TDI, VW Golf V Hatchback (1K1) 2.0 TDI 4motion, VW Golf V Hatchback (1K1) 2.0 GTI, VW Golf V Hatchback (1K1) 1.4 TSI, VW Golf V Hatchback (1K1) 2.0, VW Golf V Hatchback (1K1) 1.6 MultiFuel View more

The steps may slightly vary depending on the car design.

How to change front brake pads / front brake pad set on VW GOLF 5 (1K1) [TUTORIAL AUTODOC]

video
All the parts you need to replace – Brake Pads for Golf V Hatchback (1K1) and other VW models
Tools
Replacement: brake pads – VW Golf 5. Tools you might need:
Wire brush
Brake cleaner
Anti-squeal paste
Copper grease
HEX bit No.H7
Wheel impact socket #17
Brake caliper wind back tool
Ratchet wrench
Torque wrench
Crow bar
Wheel chock
Replacement: brake pads – VW Golf 5. AUTODOC experts recommend:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – VW Golf 5 – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    How to change Brake Pads on Golf 5 2003 - free PDF and video manuals
    Open the bonnet. Unscrew the brake fluid reservoir cap.
  2. Step 2
    How to replace VW Golf V Hatchback (1K1) 1.9 TDI 2004 Brake Pads - step-by-step manuals and video guides
    Secure the wheels with chocks.
  3. Step 3
    Golf 5 1.6 2005 Brake Pads replacement: free workshop manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  4. Step 4
    Changing Brake Pads on VW Golf V Hatchback (1K1) 1.6 FSI 2006 by yourself
    Raise the front of the car and secure on supports.
  5. Step 5
    How to remove VW GOLF 2.0 TDI 16V 2007 Brake Pads - online easy-to-follow instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. VW Golf 5
  6. Step 6
    How to replace Brake Pads on VW Golf V Hatchback (1K1) 2008: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 7
    How hard is it to do yourself: Brake Pads replacement on Golf 5 2.0 TDI 2009 - download illustrated guide
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  8. Step 8
    Need to know how to renew Brake Pads on VW GOLF 2003? This free workshop manual will help you to do it yourself
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  9. Step 9
    Changing of Brake Pads on Golf 5 2004 won't be an issue if you follow this illustrated step-by-step guide
    Spread the brake pads. Use a crowbar.
  10. Step 10
    VW GOLF 1.9 TDI Brake Pads replacement: online guides and video tutorials
    Remove the brake pads. Use a crowbar.
    Replacement: brake pads – VW Golf 5. Professionals recommend:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  11. Step 11
    Replacing Brake Pads on Golf 5 2006 1.9 TDI by yourself
    Remove the brake caliper.
    Replacement: brake pads – VW Golf 5. AUTODOC experts recommend:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  12. Step 12
    Golf V Hatchback (1K1) 2.0 TDI 16V 2007 Brake Pads DIY replacement workshop manual
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    After applying the spray, wait a few minutes.
  13. Step 13
    How to change Brake Pads on VW Golf V Hatchback (1K1) 2008 - tips and tricks
    Treat the brake caliper piston. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – VW Golf 5. After applying the spray, wait a few minutes.
  14. Step 14
    Step-by-step recommendations for DIY replacement Golf 5 2009 2.0 TDI 16V Brake Pads
    Press in the brake caliper piston. Use brake caliper wind back tool.
  15. Step 15
    DIY replacement of Brake Pads on VW Golf V Hatchback (1K1) 2.0 GTI 2003 is not an issue anymore with our step-by-step tutorial
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – VW Golf 5. Tip from AUTODOC:
    Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 2
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VW Golf V Hatchback (1K1) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VW Golf V Hatchback (1K1) Brake Pads replacement - online guide
Tips & tricks for your VW Golf V Hatchback (1K1)
View more
  • How to change Brake pad set on VW Golf V Hatchback (1K1) 2.0 GTI - replacement tricks
    What to check when buying a used car | AUTODOC tips
  • Changing Disc pads Golf 5 1.9 TDI - Replacement Tips
    How to choose the right engine oil for your car | AUTODOC
  • Maintenance Hacks - VW Golf V Hatchback (1K1) 1.6 Brake pad kit replacement guide
    How to clean an engine bay | AUTODOC
  • Replace Disc brake pads on Golf 5 - free video tips
    What causes engine misfire? | AUTODOC