Recommended replacement interval for the part category Brake pad set : 30000 km

Important!

This replacement procedure can be used for:
VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.2, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.6 Total Flex, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.0, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.0 Total Flex, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.6, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.4 TDI, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.4, VW Fox Hatchback (5Z1, 5Z3, 5Z4) 1.2 … View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Pads for Fox Hatchback (5Z1, 5Z3, 5Z4) and other VW models

Brake pad set

        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (55 hp)
      
        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (75 hp)
      
        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Diesel (70 hp)
      
        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (101 hp)
      
        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol/Ethanol (72 hp)
      
        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (72 hp)
      
        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol/Ethanol (101 hp)
      
        Brake pad set for Fox Hatchback (5Z1, 5Z3, 5Z4) Petrol (60 hp)

Replacement: brake pads – VW FOX (5Z1, 5Z3). Tools you might need:

                        Wire brush
                      
                        Nylon cleaning brush
                      
                        WD-40 spray
                      
                        Brake cleaner 
                      
                        Anti-squeal paste
                      
                        Copper grease 
                      
                        Torque wrench
                      
                        HEX bit No.H6
                      
                        Wheel impact socket #17
                      
                        Ratchet wrench
                      
                        Brake caliper wind back tool
                      
                        Crow bar
                      
                        Wheel chock

Buy tools

Replacement: brake pads – VW FOX (5Z1, 5Z3). AUTODOC experts recommend:

Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
Please note: all work on the car – VW FOX (5Z1, 5Z3) – should be done with the engine switched off.

Carry out replacement in the following order:

Step 1

Open the hood. Unscrew the brake fluid reservoir cap.

Step 2

Secure the wheels with chocks.

Step 3

Loosen the wheel mounting bolts. Use wheel impact socket #17.
Step 4

Raise the front of the car and secure on supports.

Step 5

Unscrew the wheel bolts.

AUTODOC recommends:
Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW FOX (5Z1, 5Z3)
Step 6

Remove the wheel.
Step 7

Spread the brake pads. Use a crowbar.
Step 8

Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 9

Unscrew the brake caliper fastening. Use HEX No.H6. Use a ratchet wrench.
Step 10

Remove the brake caliper.

Replacement: brake pads – VW FOX (5Z1, 5Z3). Tip:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11

Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VW FOX (5Z1, 5Z3). After applying the spray, wait a few minutes.
Step 12

Remove the brake pads.

Replacement: brake pads – VW FOX (5Z1, 5Z3). Tip from AUTODOC experts:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 13

Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VW FOX (5Z1, 5Z3). After applying the spray, wait a few minutes.
Step 14

Press in the brake caliper piston. Use brake caliper wind back tool.
Step 15

Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.

Replacement: brake pads – VW FOX (5Z1, 5Z3). Tip from AUTODOC experts:
Make sure the disc surface is clean before installing the pads.
Step 16

Install new brake pads.

Replacement: brake pads – VW FOX (5Z1, 5Z3). AUTODOC experts recommend:
Make sure the pads are installed with linings facing the disc.
Step 17

Install the brake caliper and fix it. Use HEX No.H6. Use a torque wrench. Tighten it to 25 Nm torque.
Step 18

Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 19

Clean the brake disk surface. Use a brake cleaner.

AUTODOC recommends:
Replacement: brake pads – VW FOX (5Z1, 5Z3). After applying the spray, wait a few minutes.
Step 20

Install the wheel.

AUTODOC recommends:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 21

Screw in the wheel bolts. Use wheel impact socket #17.
Step 22

Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #17. Use a torque wrench. Tighten it to 110 Nm torque.
Step 23

Remove the jacks and chocks.

Replacement: brake pads – VW FOX (5Z1, 5Z3). AUTODOC experts recommend:
Without starting the engine, press the brake pedal several times until you feel significant resistance.Check the brake fluid level in the expansion tank and refill if necessary.
Step 24

Tighten the brake fluid reservoir cap. Close the hood.

Replacement: brake pads – VW FOX (5Z1, 5Z3). AUTODOC recommends:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Fox Hatchback (5Z1, 5Z3, 5Z4) model.

Browse tyres

How to change front brake discs on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.45 MB
How to change front brake hose on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.63 MB
How to change wheel cylinder on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.39 MB
How to change rear brake shoes on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
1.91 MB
How to change front brake caliper on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.69 MB
How to change rear wheel bearing on VW Fox Hatchback (5Z1, 5Z3, 5Z4) – replacement guide

Free download PDF
2.25 MB

How to change front brake pads on VW Fox Hatchback (5Z5) – replacement guide

Free download PDF
1.5 MB
How to change brake pads on a car – replacement tutorial

Universal

Free download PDF
2.84 MB
How to change front brake pads on VW Polo 9N – replacement guide

Free download PDF
2.32 MB
How to change rear brake pads on VW Golf 7 – replacement guide

Free download PDF
1.51 MB
How to change rear brake pads on VW Golf 6 – replacement guide

Free download PDF
2.2 MB
How to change rear brake pads on VW Golf 5 – replacement guide

Free download PDF
2.38 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

Petrol or diesel? What's the difference between these engines? | AUTODOC

4K views

Published on: 04/05/2021
What to do if the TPMS light is on | AUTODOC tips

6K views

Published on: 28/09/2023
5 tools that make car repair incredibly simple | AUTODOC tips

36K views

Published on: 25/01/2024
What to do if the airbag light is on | AUTODOC tips

5K views

Published on: 10/04/2023