When to replace the Brake Pads on your VW CC
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
VW CC (358) 3.6 FSI 4motion, VW CC (358) 1.8 TSI, VW CC (358) 2.0 TFSI, VW CC (358) 1.8 TSI View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

Tools
Replacement: brake pads – VW CC (358). List of the tools you'll need:
Wire brush
Nylon cleaning brush
Brake cleaner
Anti-squeal paste
Ceramic grease
Torque wrench
HEX bit No.H7
Wheel impact socket #17
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake pads – VW CC (358). AUTODOC experts recommend:
  • Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
  • The replacement procedure is identical for all brake pads on the same axle.
  • Please note: all work on the car – VW CC (358) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the bonnet. Unscrew the brake fluid reservoir cap.
    Step 2
    Secure the wheels with chocks.
    Step 3
    How to change Brake Pads on VW CC 358 2011 - free PDF and video manuals
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  2. Step 4
    Raise the car.
    AUTODOC recommends:
    If you are using a jack, make sure it rests on a flat surface without any unevenness.Be sure to additionally secure the car with jack stands.
    Step 5
    How to replace VW CC (358) 2.0 TDI 2012 Brake Pads - step-by-step manuals and video guides
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. VW CC (358)
  3. Step 6
    VW CC 358 2.0 TDI 4motion 2013 Brake Pads replacement: free workshop manuals
    Remove the wheel.
  4. Step 7
    Changing Brake Pads on VW CC (358) 2.0 TSI 2014 by yourself
    Detach the brake caliper retaining spring. Use a crowbar.
  5. Step 8
    How to remove VW CC 3.6 FSI 4motion 2015 Brake Pads - online easy-to-follow instructions
    Spread the brake pads. Use a crowbar.
  6. Step 9
    How to replace Brake Pads on VW CC (358) 2016: download PDF manuals and video instructions
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  7. Step 10
    How hard is it to do yourself: Brake Pads replacement on VW CC 358 2.0 TDI 4motion 2011 - download illustrated guide
    Unscrew the brake caliper fasteners. Use HEX No.H7. Use a ratchet wrench.
  8. Step 11
    Need to know how to renew Brake Pads on VW CC 2012? This free workshop manual will help you to do it yourself
    Remove the brake caliper.
    AUTODOC recommends:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur.
  9. Step 12
    Changing of Brake Pads on VW CC 358 2013 won't be an issue if you follow this illustrated step-by-step guide
    Remove the brake pads.
    Replacement: brake pads – VW CC (358). Tip:
    Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
  10. Step 13
    VW CC 2.0 TSI Brake Pads replacement: online guides and video tutorials
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – VW CC (358). After applying the spray, wait a few minutes.Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  11. Step 14
    Replacing Brake Pads on VW CC 358 2015 2.0 TDI by yourself
    Remove the brake caliper guide pins.
  12. Step 15
    CC (358) 3.6 FSI 4motion 2016 Brake Pads DIY replacement workshop manual
    Clean the brake caliper guide pins. Use a brake cleaner.
    AUTODOC recommends:
    After applying the spray, wait a few minutes.
  13. Step 16
    How to change Brake Pads on VW CC (358) 2011 - tips and tricks
    Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake pads – VW CC (358). After applying the spray, wait a few minutes.
  14. Step 17
    Step-by-step recommendations for DIY replacement VW CC 358 2012 3.6 FSI 4motion Brake Pads
    Press in the brake caliper piston. Use brake caliper wind back tool.
  15. Step 18
    DIY replacement of Brake Pads on VW CC (358) 1.4 TSI 2013 is not an issue anymore with our step-by-step tutorial
    Install the brake caliper guide pins.
  16. Step 19
    How to change Brake Pads on VW CC 358 2011 - free PDF and video manuals
    Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
    Replacement: brake pads – VW CC (358). AUTODOC experts recommend:
    Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VW CC (358) Brake Pads replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VW CC (358) Brake Pads replacement - online guide
Tips & tricks for your VW CC (358)
View more
  • How to change Brake pad set on VW CC (358) 1.4 TSI - replacement tricks
    How to restore a steering wheel | AUTODOC tips
  • Changing Disc pads VW CC 358 2.0 TDI - Replacement Tips
    How to repair a chipped or cracked windscreen | AUTODOC tips
  • Maintenance Hacks - VW CC (358) 2.0 TDI 4motion Brake pad kit replacement guide
    How to clean an engine bay | AUTODOC
  • Replace Disc brake pads on VW CC 358 - free video tips
    How to polish your car | AUTODOC tips