Disclaimer
How to change front brake pads on Opel Astra H saloon – replacement guide
downloads:
6
Views:
87
Recommended replacement interval for the part category Brake pad set : 30000 km
Important!
This replacement procedure can be used for:
OPEL Astra H Saloon (A04) 1.4 (L69), OPEL Astra H Saloon (A04) 1.6 (L69), OPEL Astra H Saloon (A04) 1.7 CDTi (L69), OPEL Astra H Saloon (A04) 1.7 CDTi (L69), OPEL Astra H Saloon (A04) 1.3 CDTi (L69), OPEL Astra H Saloon (A04) 1.8 (L69) … View more
The steps may slightly vary depending on the car design.
OPEL Astra H Saloon (A04) 1.4 (L69), OPEL Astra H Saloon (A04) 1.6 (L69), OPEL Astra H Saloon (A04) 1.7 CDTi (L69), OPEL Astra H Saloon (A04) 1.7 CDTi (L69), OPEL Astra H Saloon (A04) 1.3 CDTi (L69), OPEL Astra H Saloon (A04) 1.8 (L69) … View more
The steps may slightly vary depending on the car design.
How to change front brake pads on OPEL ASTRA H Saloon [TUTORIAL AUTODOC]
All the parts you need to replace – Brake Pads for Astra H Saloon (A04) and other OPEL models
Brake pad set
Alternative products
Brake pad set
Wire brush
Nylon cleaning brush
Brake cleaner
Anti-squeal paste
Copper grease
Torque wrench
HEX bit No.H7
Wheel impact socket #17
Ratchet wrench
Brake caliper wind back tool
Crow bar
Wheel chock
Replacement: brake pads – Opel Astra H saloon. Tip:
- Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
- The replacement procedure is identical for all brake pads on the same axle.
- Please note: all work on the car – Opel Astra H saloon – should be done with the engine switched off.
Carry out replacement in the following order:
- Step 1
Open the hood. Unscrew the brake fluid reservoir cap. - Step 2Secure the wheels with chocks.Step 3
Loosen the wheel mounting bolts. Use wheel impact socket #17. - Step 4
Raise the front of the car and secure on supports. - Step 5
Unscrew the wheel bolts.AUTODOC recommends:Warning! To avoid injury, hold the wheel while unscrewing the fastening bolts. Opel Astra H saloon - Step 6
Remove the wheel. - Step 7
Remove the dust boot caps of the brake caliper guide pins. Use a crowbar. - Step 8
Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench. - Step 9
Spread the brake pads. Use a crowbar. - Step 10
Detach the brake caliper retaining spring. Use a crowbar. - Step 11
Remove the brake caliper.Replacement: brake pads – Opel Astra H saloon. Tip from AUTODOC experts:Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary. - Step 12
Remove the brake pads.Replacement: brake pads – Opel Astra H saloon. Tip from AUTODOC:Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced. - Step 13
Treat the brake caliper piston. Use a nylon cleaning brush. Use a brake cleaner.AUTODOC recommends:Replacement: brake pads – Opel Astra H saloon. After applying the spray, wait a few minutes. - Step 14
Press in the brake caliper piston. Use brake caliper wind back tool. - Step 15
Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.Replacement: brake pads – Opel Astra H saloon. Tip from AUTODOC experts:After applying the spray, wait a few minutes. - Step 16
Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.Replacement: brake pads – Opel Astra H saloon. AUTODOC experts recommend:Make sure the disc surface is clean before installing the pads.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Searching for the right tyres?
Find out which tyre and wheel sizes are compatible with the OPEL Astra H Saloon (A04) model.
Popular maintenance tutorials for Opel Astra H Saloon
Free download PDF
2.34 MB
Free download PDF1.67 MB
Free download PDF2.22 MB
Free download PDF2.09 MB
Free download PDF2.77 MB
Free download PDF2.95 MB
Complete guides for changing the Brake pad set on different OPEL ASTRA models
Free download PDF2.32 MB
Free download PDF1.45 MB
Free download PDF1.45 MB
Free download PDF2.3 MB
Free download PDF2.54 MB
Free download PDF2.35 MB
Your profile is your personal assistant.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- - scan the QR code
- - download from App Store
- - download from Google Play
Tips & tricks for your OPEL Astra H Saloon (A04)
View more
5 Tips for New Drivers | AUTODOC tips
What to do if the belt squeals | AUTODOC tips
The Ultimate Guide to Engine Bay Cleaning | AUTODOC
Top 5 brake repair mistakes | AUTODOC tips
