Replacement: brake pads – HONDA JAZZ IV (GK). AUTODOC recommends:
Perform the replacement of brake pads in complete set for each axis. This provides effective braking.
The replacement procedure is identical for all brake pads on the same axle.
All work should be done with the engine stopped.
Replacement: brake pads – HONDA JAZZ IV (GK). Take the following steps:
Step 1
Open the bonnet. Unscrew the brake fluid reservoir cap.
Step 2
Secure the wheels with chocks.
Step 3
Loosen the wheel mounting bolts. Use wheel impact socket #19.
Step 4
Raise the front of the car and secure on supports.
Step 5
Unscrew the wheel bolts.
AUTODOC recommends:
Important! Hold the wheel while unscrewing the fastening bolts. HONDA JAZZ IV (GK)
Step 6
Remove the wheel.
Step 7
Clean the brake caliper fasteners. Use a wire brush. Use WD-40 spray.
Step 8
Spread the brake pads. Use a crowbar.
Step 9
Unscrew the brake caliper fastening. Use a drive socket #12. Use a ratchet wrench.
Step 10
Remove the brake caliper.
Replacement: brake pads – HONDA JAZZ IV (GK). Professionals recommend:
Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
Step 11
Remove the brake pads. Use a crowbar.
Replacement: brake pads – HONDA JAZZ IV (GK). AUTODOC experts recommend:
Measure the brake disc thickness. Upon reaching the wear limit the part must be replaced.
Step 12
Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
AUTODOC recommends:
Replacement: brake pads – HONDA JAZZ IV (GK). After applying the spray, wait a few minutes.
Step 13
Treat the brake caliper piston. Use a brake cleaner.
Replacement: brake pads – HONDA JAZZ IV (GK). Tip from AUTODOC:
After applying the spray, wait a few minutes.
Step 14
Press in the brake caliper piston. Use brake caliper wind back tool.
Step 15
Treat the brake pads in the area where their surface comes into contact with the brake caliper bracket. Use anti-squeal paste.
Replacement: brake pads – HONDA JAZZ IV (GK). Tip from AUTODOC experts:
Make sure the disc surface is clean before installing the pads.
Step 16
Install new brake pads.
Replacement: brake pads – HONDA JAZZ IV (GK). Tip:
Make sure the pads are installed with linings facing the disc.
Step 17
Install the brake caliper and fix it. Use a drive socket #12. Use a torque wrench. Tighten it to 23 Nm torque.
Step 18
Treat the surface where the brake disc contacts the wheel rim. Use copper grease.
Step 19
Clean the brake disk surface. Use a brake cleaner.
AUTODOC recommends:
Replacement: brake pads – HONDA JAZZ IV (GK). After applying the spray, wait a few minutes.
Step 20
Install the wheel.
Replacement: brake pads – HONDA JAZZ IV (GK). AUTODOC recommends:
To avoid injury, hold up the wheel when screwing in the fastening bolts.
Step 21
Screw in the wheel bolts. Use wheel impact socket #19.
Step 22
Lower the car and working in a cross order, tighten the wheel bolts. Use wheel impact socket #19. Use a torque wrench. Tighten it to 108 Nm torque.
Step 23
Remove the jacks and chocks.
AUTODOC recommends:
Important! Replacement: brake pads – HONDA JAZZ IV (GK). Check the brake fluid level in the reservoir and top up if necessary.
Step 24
Tighten the brake fluid reservoir cap.
AUTODOC recommends:
HONDA JAZZ IV (GK) – Without starting the engine, press the brake pedal several times until it feels firm.
Step 25
Close the hood.
Replacement: brake pads – HONDA JAZZ IV (GK). Professionals recommend:
Slow down smoothly for first 150-200 km after the brake pads replacement. Avoid unneccessary and sharp braking to a stop.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents
Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
Scan
To download the app:
- scan the QR code
- download from App Store
- download from Google Play
Tips & tricks for your HONDA JAZZ IV (GK)
View more
What to do if the ABS light comes on | AUTODOC tips
5 mistakes made when washing the engine | AUTODOC tips