When to replace the Brake Discs on your VW SCIROCCO
Recommended replacement interval for the part category Brake disc : 50000 km
Important!
This replacement procedure can be used for:
VW SCIROCCO (137, 138) 2.0 R, VW SCIROCCO (137, 138) 2.0 TDI, VW SCIROCCO (137, 138) 1.4 TSI, VW SCIROCCO (137, 138) 1.4 TSI, VW SCIROCCO (137, 138) 2.0 TDI, VW SCIROCCO (137, 138) 2.0 TFSI, VW SCIROCCO (137, 138) 2.0 TDI, VW SCIROCCO (137, 138) 2.0 TSI, VW SCIROCCO (137, 138) 2.0 R, VW SCIROCCO (137, 138) 2.0 TDI, VW SCIROCCO (137, 138) 1.4 TSI, VW SCIROCCO (137, 138) 2.0 TDI, VW SCIROCCO (137, 138) 2.0 TSI, VW SCIROCCO (137, 138) 2.0 TSI, VW SCIROCCO (137, 138) 2.0 TDI, VW SCIROCCO (137, 138) 2.0 R, VW SCIROCCO (137, 138) 1.4 TSI View more

The steps may slightly vary depending on the car design.

This video shows the replacement procedure of a similar car part on another vehicle

All the parts you need to replace – Brake Discs for SCIROCCO (137, 138) and other VW models
Tools
Replacement: brake discs – VW SCIROCCO (137, 138). List of the tools you'll need:
Wire brush
Nylon cleaning brush
WD-40 spray
Brake cleaner
Copper grease
Torque wrench
Drive socket # 21
HEX bit No.H7
Torx bit T27
Torx bit T30
Wheel impact socket #17
Ratchet wrench
Tap wrench
Rubber mallet
Impact screwdriver
Brake caliper wind back tool
Crow bar
Wheel chock
AUTODOC recommends:
  • Replace the brake disks on the car VW SCIROCCO (137, 138) in complete set for each axis. Regardless of the state of components. This will ensure even braking.
  • The replacement procedure is identical for both brake disks on the same axle.
  • When changing the brake discs, always replace the brake pads.
  • Please note: all work on the car – VW SCIROCCO (137, 138) – should be done with the engine switched off.
Carry out replacement in the following order:
  1. Step 1
    Open the hood.
    Step 2
    How to change Brake Discs on Scirocco Mk3 2008 - free PDF and video manuals
    Clean the brake fluid reservoir cap. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – VW SCIROCCO (137, 138). After applying the spray, wait a few minutes.
  2. Step 3
    How to replace VW SCIROCCO (137, 138) 1.4 TSI 2009 Brake Discs - step-by-step manuals and video guides
    Unscrew the engine solenoid valve bracket. Use Torx T27. Use a ratchet wrench.
  3. Step 4
    Scirocco Mk3 2.0 TDI 2010 Brake Discs replacement: free workshop manuals
    Unscrew the brake fluid reservoir cap.
  4. Step 5
    Secure the wheels with chocks.
    Step 6
    Changing Brake Discs on VW SCIROCCO (137, 138) 2.0 R 2011 by yourself
    Loosen the wheel mounting bolts. Use wheel impact socket #17.
  5. Step 7
    Raise the front of the car and secure on supports.
    Step 8
    How to remove VW SCIROCCO 2.0 TSI 2012 Brake Discs - online easy-to-follow instructions
    Unscrew the wheel bolts.
    AUTODOC recommends:
    Important! Hold the wheel while unscrewing the fastening bolts. VW SCIROCCO (137, 138)
  6. Step 9
    How to replace Brake Discs on VW SCIROCCO (137, 138) 2013: download PDF manuals and video instructions
    Remove the wheel.
  7. Step 10
    How hard is it to do yourself: Brake Discs replacement on Scirocco Mk3 2.0 TDI 2014 - download illustrated guide
    Spread the brake pads. Use a crowbar.
  8. Step 11
    Need to know how to renew Brake Discs on VW SCIROCCO 2015? This free workshop manual will help you to do it yourself
    Remove the dust boot caps of the brake caliper guide pins. Use a crowbar.
  9. Step 12
    Changing of Brake Discs on Scirocco Mk3 2016 won't be an issue if you follow this illustrated step-by-step guide
    Unscrew the brake caliper fastening. Use HEX No.H7. Use a ratchet wrench.
  10. Step 13
    VW SCIROCCO 2.0 R Brake Discs replacement: online guides and video tutorials
    Detach the brake caliper retaining spring. Use a crowbar.
  11. Step 14
    Replacing Brake Discs on Scirocco Mk3 2008 1.4 TSI by yourself
    Remove the brake caliper.
    Replacement: brake discs – VW SCIROCCO (137, 138). Tip:
    Tie the caliper to the suspension or to the body with a wire without disconnecting from the brake hose to prevent depressurization of the brake system.Make sure that the brake caliper is not hanging on the brake hose.Don't press the brake pedal after the brake caliper has been removed. As a result, the piston can fall out from the brake cylinder, and brake fluid leakage and depressurization of the system may occur. Check the brake caliper bracket, brake caliper guide pins and boots. Clean them. Replace, if necessary.
  12. Step 15
    SCIROCCO (137, 138) 2.0 TSI 2009 Brake Discs DIY replacement workshop manual
    Remove the brake pads.
  13. Step 16
    How to change Brake Discs on VW SCIROCCO (137, 138) 2010 - tips and tricks
    Clean the brake caliper bracket fasteners. Use a wire brush. Use WD-40 spray.
  14. Step 17
    Step-by-step recommendations for DIY replacement Scirocco Mk3 2011 2.0 TSI Brake Discs
    Unscrew the caliper bracket fastening. Use a drive socket #21. Use a ratchet wrench. Use a tap wrench.
  15. Step 18
    DIY replacement of Brake Discs on VW SCIROCCO (137, 138) 2.0 TFSI 2012 is not an issue anymore with our step-by-step tutorial
    Remove the caliper bracket.
  16. Step 19
    How to change Brake Discs on Scirocco Mk3 2008 - free PDF and video manuals
    Clean the brake disc fastener. Use a wire brush. Use WD-40 spray.
  17. Step 20
    How to replace VW SCIROCCO (137, 138) 1.4 TSI 2009 Brake Discs - step-by-step manuals and video guides
    Unscrew the brake disc fastening. Use Torx T30. Use an impact screwdriver.
  18. Step 21
    Scirocco Mk3 2.0 TDI 2010 Brake Discs replacement: free workshop manuals
    Remove the brake disc. Use a rubber mallet.
  19. Step 22
    Changing Brake Discs on VW SCIROCCO (137, 138) 2.0 R 2011 by yourself
    Clean the hub. Use a wire brush. Treat the contacting surface. Use copper grease.
  20. Step 23
    How to remove VW SCIROCCO 2.0 TSI 2012 Brake Discs - online easy-to-follow instructions
    Install the brake disc.
  21. Step 24
    How to replace Brake Discs on VW SCIROCCO (137, 138) 2013: download PDF manuals and video instructions
    Tighten the brake disc fastening. Use Torx T30. Use a torque wrench. Tighten it to 4 Nm torque.
  22. Step 25
    How hard is it to do yourself: Brake Discs replacement on Scirocco Mk3 2.0 TDI 2014 - download illustrated guide
    Clean the brake caliper bracket from dirt and dust. Use a wire brush. Use a brake cleaner.
    AUTODOC recommends:
    Replacement: brake discs – VW SCIROCCO (137, 138). After applying the spray, wait a few minutes.
Was this manual helpful?
Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.
Users voted – 0
Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!
Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.
VW SCIROCCO (137, 138) Brake Discs replace by yourself - Scan QR-code and download AUTODOC CLUB app
Scan

To download the app:

  • - scan the QR code
  • - download from App Store
  • - download from Google Play
DIY VW SCIROCCO (137, 138) Brake Discs replacement - online guide
Tips & tricks for your VW SCIROCCO (137, 138)
View more
  • How to change Brake rotors on VW SCIROCCO (137, 138) 2.0 TFSI - replacement tricks
    What to do if the ABS light comes on | AUTODOC tips
  • Changing Brake disc Scirocco Mk3 1.4 TSI - Replacement Tips
    How to remove scratches from car plastic | AUTODOC tips
  • Maintenance Hacks - VW SCIROCCO (137, 138) 2.0 TDI Brake disc kit replacement guide
    Why do your brakes squeak? | AUTODOC tips
  • Replace Disc brake set on Scirocco Mk3 - free video tips
    How to Make a DIY Foam Sprayer | AUTODOC tips