Recommended replacement interval for the part category Oil filter : 1 year / 20000 km

Important!

This replacement procedure can be used for:
FIAT PUNTO (188) 1.2 Natural Power, FIAT PUNTO (188) 1.2 16V 80 (188.233, .235, .253, .255, .333, .353, .639,..., FIAT PUNTO (188) 1.4 … View more

The steps may slightly vary depending on the car design.

How to change oil filter and engine oil on FIAT PUNTO 2 (188) [TUTORIAL AUTODOC]

All the parts you need to replace – Oil Filter for PUNTO (188) and other FIAT models

Oil filter

        Oil filter for Punto II Hatchback (188) Petrol (80 hp)
      
        Oil filter for Punto II Hatchback (188) Petrol (95 hp)
      
        Oil filter for Punto II Hatchback (188) Petrol/Natural Gas (CNG) (60 hp)

Replacement: engine oil and filter – Fiat Punto 188. Tools you'll need:

                        All-purpose cleaning spray
                      
                        Oil filter cup socket 76-14F
                      
                        HEX bit no.H12.
                      
                        Ratchet wrench
                      
                        Torque wrench
                      
                        Oil drain pan
                      
                        Funnel
                      
                        Fender cover

Buy tools

Replacement: engine oil and filter – Fiat Punto 188. AUTODOC recommends:

Replace the oil filter every time when changing motor oil.
Use only new O-rings during installation.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Replacement: engine oil and filter – Fiat Punto 188. Use the following procedure:

Step 1

Open the hood.
Step 2

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.
Step 3

Remove the cap of the oil filler neck.
Step 4

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – Fiat Punto 188. Tip:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.
Step 5

Put a waste oil container with at least 3 l capacity under the drainage hole.
Step 6

Unscrew the drain plug. Use HEX No.H12. Use a ratchet wrench.
Step 7

Drain the used oil.

Replacement: engine oil and filter – Fiat Punto 188. Professionals recommend:
Caution! The oil may be hot.
Step 8

Clean the oil filter seat. Use all-purpose cleaning spray.
Step 9

Prepare a container for the old oil filter.

Step 10

Unscrew the oil filter. Use the 76-14F socket. Use a ratchet wrench.
Step 11

Put the old oil filter in the container.

Replacement: engine oil and filter – Fiat Punto 188. Tip from AUTODOC experts:
Move up the container. The oil starts to drain out of the drainage hole immediately after you have removed the oil filter.
Step 12

Clean the oil filter seat.
Step 13

Lubricate the rubber seal of the new filter with a little amount of fresh oil.
Step 14

Screw the new filter into its place. Use the 76-14F socket. Use a torque wrench. Tighten it to 18 Nm torque.

Replacement: engine oil and filter – Fiat Punto 188. Tip from AUTODOC:
Wait until the oil has completely drained from the drainage hole.
Step 15

Clean the area of the oil pan drainage hole.

Step 16

Screw in the new drainage plug and tighten it. Use HEX No.H12. Use a torque wrench. Tighten it to 27 Nm torque.
Step 17

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.

Step 18

Lower the car.
Step 19

Remove the oil filler cap.
Step 20

Insert the funnel.
Step 21

Pour oil into the engine through the filler. Required amount of oil: 2.6 l.

Replacement: engine oil and filter – Fiat Punto 188. AUTODOC experts recommend:
Use the oil recommended by the manufacturer.
Step 22

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 23

Install the oil filler cap.

Step 24

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.
Step 25

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Please note!
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 26

Remove the fender protection cover.
Step 27

Close the hood.

Replacement: engine oil and filter – Fiat Punto 188. AUTODOC recommends:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the FIAT Punto II Hatchback (188) model.

Browse tyres

How to change fuel filter on Fiat Punto 188 diesel – replacement guide

Free download PDF
1.67 MB
How to change engine oil and filter on Fiat Punto 188 diesel – replacement guide

Free download PDF
2.1 MB
How to change pollen filter on Fiat Punto 188 – replacement guide

Free download PDF
1.66 MB
How to change air filter on Fiat Punto 188 – replacement guide

Free download PDF
1.88 MB
How to change front brake pads on Fiat Punto 188 – replacement guide

Free download PDF
1.61 MB
How to change front brake discs on Fiat Punto 188 – replacement guide

Free download PDF
2.07 MB

How to change engine oil and filter on FIAT PUNTO EVO (199) – replacement guide

Free download PDF
1.89 MB
How to change engine oil and filter on Fiat Punto 188 diesel – replacement guide

Free download PDF
2.1 MB
How to change engine oil and filter on FIAT PUNTO (199) – replacement guide

Free download PDF
1.89 MB
How to change engine oil and filter on FIAT PUNTO (176) – replacement guide

Free download PDF
1.88 MB
How to change engine oil and filter on FIAT PUNTO Convertible (176C) – replacement guide

Free download PDF
1.88 MB
How to change engine oil and filter on a car – replacement tutorial

Universal

Free download PDF
2.82 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

How to check your head gasket | AUTODOC

9K views

Published on: 13/10/2020
What to do if your car's air conditioning isn't working properly | AUTODOC tips

6K views

Published on: 05/08/2021
How to fix your car with AUTODOC CLUB

16K views

Published on: 30/11/2021
Top 5 brake repair mistakes | AUTODOC tips

184K views

Published on: 27/10/2022