Recommended replacement interval for the part category Oil filter : 12 month / 15000 km

Important!

This replacement procedure can be used for:
VW PASSAT Variant (3B6) 1.8 4motion, VW PASSAT Variant (3B6) 1.8 T … View more

The steps may slightly vary depending on the car design.

How to change Engine Oil and Oil filter on VW PASSAT B5+ TUTORIAL | AUTODOC

All the parts you need to replace – Oil Filter for PASSAT Variant (3B6) and other VW models

Alternative products

Oil filter

SKOF-0860068 STARK Oil filter

6,78 GBP

Shop

23.164.03 UFI Oil filter

6,84 GBP

Shop

V10-0321 VAICO Oil filter

7,48 GBP

Shop

7O0069P RIDEX PLUS Oil filter

9,95 GBP

Shop

F 026 407 004 BOSCH Oil filter

10,57 GBP

Shop

586015 VALEO Oil filter

10,59 GBP

Shop

OC 470 MAHLE ORIGINAL Oil filter

10,75 GBP

Shop

111 164 TOPRAN Oil filter

11,86 GBP

Shop

OC 470 KNECHT Oil filter

12,55 GBP

Shop

W 940/66 MANN-FILTER Oil filter

13,54 GBP

Shop

Replacement: engine oil and filter – VW Passat B5 Variant. Tools you'll need:

                      All-purpose cleaning spray
                    
                      Drive socket # 19 
                    
                      Oil filter cup socket 76-14F
                    
                      Ratchet wrench
                    
                      Torque wrench
                    
                      Oil drain pan
                    
                      Funnel
                    
                      Fender cover

Buy tools

Replacement: engine oil and filter – VW Passat B5 Variant. AUTODOC experts recommend:

Replace the oil filter every time when changing motor oil.
Wear gloves to prevent contact with hot liquid.
All work should be done with the engine stopped.

Replacement: engine oil and filter – VW Passat B5 Variant. Take the following steps:

Step 1

Lift the car using a jack or place it over an inspection pit.

Replacement: engine oil and filter – VW Passat B5 Variant. Tip from AUTODOC experts:
The vehicle must be on even keel, and if it is at an angle, the drain plug must be at the lowest point.All work should be done with the engine stopped.
Step 2

Loosen the oil filter. Use the 76-14F socket.
Step 3

Prepare a container for the old oil filter.

Step 4

Unscrew the oil filter.
Step 5

Put the old filter cartridge in the container.
Step 6

Clean the area of the oil pan drainage hole. Use all-purpose cleaning spray.

Step 7

Screw the new filter into its place. Use the 76-14F socket. Use a torque wrench. Tighten it to 20 Nm torque.
Step 8

Put a waste oil container with at least 5 l capacity under the drainage hole.
Step 9

Unscrew the drain plug. Use a drive socket #19. Use a ratchet wrench.
Step 10

Drain the used oil.

Replacement: engine oil and filter – VW Passat B5 Variant. Tip from AUTODOC:
Caution! The oil may be hot.Wait until the oil has completely drained from the drainage hole.
Step 11

Clean the area of the oil pan drainage hole.

Step 12

Screw in the new drainage plug and tighten it. Use a drive socket #19. Use a torque wrench. Tighten it to 30 Nm torque.
Step 13

Clean the area of the oil pan drainage hole.
Step 14

Remove the container with used oil from under the car.

Step 15

Lower the car.

Step 16

Open the hood.
Step 17

Use a fender protection cover to prevent damaging paintwork and plastic parts of the car.

Step 18

Unscrew the oil filler plug. Insert the funnel.
Step 19

Pour oil into the engine through the filler. Required amount of oil: 4.3 L.

Replacement: engine oil and filter – VW Passat B5 Variant. Tip:
Use the oil recommended by the manufacturer.
Step 20

Check the oil level using the dipstick. Top up oil if necessary.

Please note!
The oil level should be between the Min and Max marks.
Step 21

Tighten the oil filler cap.
Step 22

Run the engine for a few minutes. After the oil pressure warning light goes out, stop the engine.
Step 23

Check the oil level 5 minutes after the stop of the engine operation using a dipstick and add oil if necessary.

Replacement: engine oil and filter – VW Passat B5 Variant. Tip from AUTODOC:
The oil level should be between the Min and Max marks.Make sure that the oil filler cap is properly tightened.Check the threaded plug of the drainage hole and the oil filter seal for tightness. If necessary, carefully tighten them up.
Step 24

Remove the fender protection cover.

Step 25

Close the hood.

Replacement: engine oil and filter – VW Passat B5 Variant. Professionals recommend:
Note that oil pressure warning light, which indicates insufficient pressure in the lubrication system, may be on for a longer time than usual. After a few seconds, the oil will fill all the channels, and the light will go out. To protect the environment from pollution, be sure to dispose of the used filters at special collection points.

Was this manual helpful?

Please rate this manual on a scale from 1 to 5. If you have any questions, feel free to ask us.

Searching for the right tyres?

Find out which tyre and wheel sizes are compatible with the VW Passat B5 GP Estate (3BG, 3B6) model.

Passat 3B6 tyre size

How to change fuel filter on VW Passat B5 Variant diesel – replacement guide

Free download PDF
1.49 MB
How to change fuel filter on VW Passat B5 Variant petrol – replacement guide

Free download PDF
952.32 KB
How to change engine oil and filter on VW Passat B5 Variant diesel – replacement guide

Free download PDF
2.3 MB
How to change pollen filter on VW Passat B5 Variant – replacement guide

Free download PDF
952.32 KB
How to change air filter on VW Passat B5 Variant – replacement guide

Free download PDF
1.28 MB
How to change front brake pads on VW Passat B5 Variant – replacement guide

Free download PDF
1.73 MB

How to change engine oil and filter on VW Passat Saloon (3C2) – replacement guide

Free download PDF
1.69 MB
How to change engine oil and filter on VW Passat B8 Variant (3G5, CB5) – replacement guide

Free download PDF
1.61 MB
How to change engine oil and filter on VW Passat CC (357) – replacement guide

Free download PDF
1.7 MB
How to change engine oil and filter on VW Passat Variant (365) – replacement guide

Free download PDF
1.69 MB
How to change engine oil and filter on VW Passat 3C B6 Variant – replacement guide

Free download PDF
2.27 MB
How to change engine oil and filter on VW Passat B8 Saloon (3G2, CB2) – replacement guide

Free download PDF
1.61 MB

Your profile is your personal assistant.

It can track car expenses, keep a car log and replacement schedule, and save favourite materials, notes and documents

Install the AUTODOC CLUB app!

Your personal car expenses manager, maintenance tips, reminders about upcoming appointments and service intervals, DIY repair instructions – all this on your phone.

Scan

To download the app:

- scan the QR code
- download from App Store
- download from Google Play

5 tools that make car repair incredibly simple | AUTODOC tips

41K views

Published on: 25/01/2024
What to do if your car’s bonnet won’t open | AUTODOC tips

3K views

Published on: 12/09/2024
DIY brake caliper restoration | AUTODOC tips

615K views

Published on: 02/06/2022
#DIY Guide: How to Fix a Cracked Windscreen Without a Garage Visit

8K views

Published on: 14/12/2023